华商宝

深圳汇润科技有限公司

承认书

                              SPECIFICATION FOR APPROVAL

客户/CUSTOMER           :深圳汇润科技有限公司

产品名称/PRODUCT NAME  ：电源供应器/SWITCHING POWER SUPPLY

产品编号/ OUR P/N         ：G690209015031RC4017012L30B10

产品型号/ OUR MODEL NO ：HR—003澳规

客户编号/ CUSTOMER P/N   ：

标准/STANDARD           ：

额定/：RATING           ：

I/P:AC100-240V 0.5A 50/60HZ

O/P:  DC9V 1--1.5A

备注/：REMARK          ：                            

注意：在贵司出单前请回签如下项目/Attention: Before placing orders, please confirm to sign back the followings:

□   产品规格书/Production Spec

□   铭牌规格（如有）/Nameplate Spec(if any)

□   包装规格（如有）/Packing Spec(if any)

版本/REV.

描述/DESCRIPTION

日期/DATA

00

首次发行

2010-4-14

公司确认栏

INTERNAL CONFIRMATION

客户/CUSTOMER

制作/

DRAW BY

核准/

CHECKED BY

日期/

DATA

确认/ APPROVED BY

（签字或盖章）

      （signature and stamp）

                                            索引/INDEX

1、        描述/Introduction

2、        输入特性/Input Characteristic

3、        输出特性/Output Characteristic

4、        规格要求/Performance Spec

5、        保护特点/Protection Features

6、        环境/Environmental

7、        绝缘耐压测试/Dielectric withstand (Hi-pot) test

8、        绝缘阻抗测试/Insulation Resistance Test

9、        产品可靠性/ product MTBF

10、   重要安全要求/Important Safety Instructions

11、   主要测量设备/Major measure equipment

12、   铭牌/Nameplate

13、   产品外观/Product external appearance

1描述/Introduction

  这个文件描述的是用PWM设计的反激变换器的特性：/This document presents performance characteristics of an isolated flyback converter moduledesigned with PWM:有非常好的保护功能：过压保护，过流保护，过功率保护/very good protect function: over voltage protection, over current protection, over power protection

2      输入特性/Input Characteristic

  额定AC输入电压AC100V-240V/AC input voltage rating AC 100V to 240V

AC输入电压范围AC90V-264/AC input voltage range AC 90V to 264V

AC输入频率47HZ to 63HZ /AC input frequency 47HZ to 63HZ

输入100VAC/50HZ满载时最大浪涌电流30A，输入240VAC/50HZ满载时最大浪涌电流75A/Max. In-rush current 30 A for 100VAC/50HZ at full load(At cold Start ) 75 A for 240VAC/50HZ at full load

输入电流0.5A(rms)最大在满载90V ac~132Vac/60HZ,输入电流0.3A(rms)最大在满载180V ac~240Vac/50HZ。Input Current0.5A(rms) max. @ full load, 90Vac~132Vac/60HZ, Input Current0.3A(rms) max. @ full load, 180Vac~240Vac/50HZ

电流保险丝2.0A/Fuse Current 2.0A

3  输出特性/Output Characteristic

备注/Note:

*规格书上的输出电压范围包含电线的负载电压/Specified output regulation limit includes line and load regulation.

*纹波与噪音的测试条件:测试时在输出端并联一个10uF的电解电容和

一个0.1uF的瓷片电容,标准测试频带DC-20MHz/Ripple and Noise is measured on output connector with 20MHz oscilloscope bandwidth differentially with a 10uF electrolitic and 0.1uF ceramic capacitors across output

4     规格要求/Performance Spec

   输出总功率16.9--18W典型值/Total Output Power16.9W Typical

待机功耗<0.4W @90Vac/63Hz~264Vac/47Hz,空载./ Standby Power < 0.4W @ 90Vac/63Hz~264Vac/47Hz, no load.

郊率75%最小@90Vac/60HZ满载/Efficiency 75％min. @ 90Vac/60HZ with full load

支撑时间10 msec最小@100Vac/60HZ满载/Hold up Time 10m sec. min. @ 100Vac/60HZ with full load

起动时间5Sec最大@100Vac/60HZ满载/Turn on Delay Time 5 sec. max. @ 100Vac/60HZ with full load

开关频率典型值65K/Switching frequency 65K Typical

5保护特点/Protection Features

  短路保护保护后停止输出（撤销短路自动恢复）/ Short circuit Protection  Output shut down (Auto recovery)

  过压保护/ Over Voltage Protection.

  过流保护/ Over Current Protection.

6环境/Environmental

    工作温度0℃to + 35℃/Operating Temperature 0℃ to + 35℃

工作湿度20 % to 90 % R. H./Operating Humidity 20 % to 90 % R. H

储存温度-40℃to 85 ℃/Storage Temperature -40 ℃ to 85 ℃

储存湿度0 % to + 90 % R. H /Storage Humidity 0 % to + 90 % R. H.

7     绝缘耐压测试/Dielectric withstand (Hi-pot) test

输入对输出3300Vac/10Ma/3S/Input to Output3300Vac/10Ma/3S

8     绝缘阻抗测试/Insulation Resistance Test

   输入对输出DC500V 4M  ohm最小/Input to Output DC 500V 4M ohm min.

9     产品可靠性/ product MTBF

产品可靠性最少2000小时@25℃满载/MTBF 2000Hour min of Full load.

 产品可靠性最少4000小时@25℃80%负载/MTBF 4000Hour min of 80% load.

10重要安全要求/Important Safety Instructions

使用前请先阅读说明书/Read these instructions.

不要将产品放在靠近水源的地方/Do not use this apparatus near water.

只能用干抹布清洁/Clean only with dry cloth.

请不要将产品放近发热器附近，如，辐射源热储存器，炉，以及生热的产品/Do not install near any heat sources such as radiators, heat registers, stoves,or other apparatus (including amplifiers) that produce heat.

如长时间不用，或闪电时，请拔掉插头/Mains plug is disconnect device. Unplug this apparatus during lightning storms or when unused for long periods of time.

11主要测量设备/ Major measure equipment

交流输入电源/AC SOURCE.  APW105

电子负载/ELECTRONIC LOAD:TR368  

数字万用表/DIGIAL MASTECH:GDM-8145

    示波器/OSCILLOSCOPE: TD1012B

耐压测试仪/HI-POT TESTER:7112  

绝缘阻抗测试仪/Insulation Resistance 7112

 多通道温度测试仪/THERMOMETER:DWG-2

12铭牌/Nameplate

备注/REMARK:白底黑字/White bottom black word

13产品外观/Product external appearance

膠殼顏色/Color of enclosure:黑色/Black